The Versys Thread
 

I have added to my Kawasaki stable with a Versys Tourer.

http://farm9.staticflickr.com/8282/7...8cc81393_c.jpg

The Tourer gets the MRA Vario screen, handguards, a gel tank pad and panniers which are marked Kawasaki but are Givi Monokey.

An odd issue is that Kawasaki will not let you buy a top box with the panniers, it is either or, not both. But you can get the three boxes elsewhere, such as Givi. It is supposedly down to weight, but that seems a bit odd. It was not a deal killer for me and I am happy with my Weise Expander tail bag secured under the seat with the strap and bungees. There is hardly any space under the seat anyway.

I got the bike after touring a lot on the KLE500 and finding it underpowered and uncomfortable. But I am keeping the KLE500 for the winter and off road where it really excels. The Versys will be on road only, with the odd dirt track, but nothing more. I have seen film of a Versys with a sump guard being ridden properly off road over rocks and jumps, but the low exhaust means that is not really its best environment.

MotoUSA Project Bike: Kawasaki Versys Part 3 - YouTube

One nod to going off road is the Motowerk Flat Foot (the oily smudges are from giving it a good going over with ACF50)

http://farm9.staticflickr.com/8428/7...91f06619_c.jpg

though since the first time I parked the bike and left it for a while I found the side stand had sunk into the tarmac, it will be useful all of the time. There is no provision for a centre stand due to the exhaust.

I cannot wait to get some proper miles on the clock. It is an odd mix of bike. Tall sports tourer with a bit of off road and commuting thrown in. It certainly is not a direct replacement for the KLE500, bit they nicely complement each other.

With panniers and tail bag.

http://farm9.staticflickr.com/8448/7...2c0bcf36_b.jpg

Thats 105 litres of capacity between the three.

And another one
 

Me too!
I have just got one for the road riding - I've no intention of going off road with it; mine has a similar spec to yours but with the topbox and not the panniers - I like the (very) low exhaust which means I can just throw some soft luggage over the pillion seat, easily.


Your thread title is a bit misleading in that there is also a Kawasaki versys 1000cc but, hey, I knew what you meant.
There isn't much discussion of this KLE 650 in here but, never mind, a "best kept secret" maybe?

ps I've just found one of those earlier threads that you might enjoy reading
http://www.horizonsunlimited.com/hub...ng-guide-64799

Hurrah! Another owner owner!

Mine just went in for its 600 mile service, £112. I have now got engine guards, a fender extender and a tool tube fitted. I am trying out a bumbag4bikers

3um3ags43ikers

which is a pad filled with buckwheat like a bean bag. It certainly dampens the vibrations and so far so good.

I can now use more revs and will have a proper tour soon.

I am disappointed with the finish as there are marks where my heel rests on the frame and I did have my pannier key with the ignition key and it has left marks too.

"They all do that sir".
Actually, most bikes do especially in the way you describe at the headstock - caused by the dangling keys.
It all adds to the street cred?

As an after-thought, I have been reading back into the thread below, which gives a pretty good review about riding the wee Versys (since there is now a big versys with the 1000cc inline 4 engine!!) with full luggage and a pillion.
http://www.horizonsunlimited.com/hub...i-versys-53856

Kle650caf
 

The Versys KLE650CAF (non ABS) - a road bike.
Just for clarity, I'm referring here to the second version that has been on sale most recently, specifically a 2010 bike. Reputedly, these have a less vibey engine compared with the first version, being mounted differently.


I have owned mine for just over 2 months and put in nearly 3500 miles, all on the highway – this is not an off road bike! Yes, it's not a vast mileage but enough to make a judgement about the Versys. So what I am saying here is simply my experience of riding this bike for quite a short time but over a few miles.
Most of the miles have been one up with luggage by the way, but I have carried a pillion a few times, with no significant luggage fitted on those occasions.
The bike is shod with Michelin road pilot 3s which have a load of grip; very likely far more than this bike needs.


Comfort:
The handbook says the ground clearance is 7 inches; this seems really good on the face of it, but the bike is a road bike i.e. it doesn't actually need this amount of clearance for road use and it does mean that the seat is quite high. Lots of information/reports about the Versys have pointed out the under-slung exhaust collection box which is just forward of the back wheel – this may be why the ground clearance is so high.
Sure, the bike does have a high ground clearance for a road bike, but, as a consequence, the foot pegs are a bit too high, for me anyway. I certainly expected them to be lower and more comfortable in that important dimension between seat and foot pegs which determines the amount of bend in the knees – a big contributing factor to all day riding comfort and putting in the distance.
Everything else about the bike e.g. the stretch to the handle bars and the saddle are fine for me when putting in 300+ miles per day (but then so was the F650GS when doing 500+ mile days).
The overall riding position feels “high” because of the high seat position and the wide spread of the handle bars; it is quite possible to stand on the pegs while riding thereby easing the knees!
My pillion says that the rear part of the saddle is very comfortable.


Range:
The fuel tank is quoted as 19 litres capacity and it certainly can return about 250 miles between fill ups; the fuel warning starts to flash when there is about a gallon (UK gallon, i.e. about 4.5 litres) remaining. So, you can easily push this on a bit with the knowledge that it is not going to run out of fuel for some time – I have got to within about 2 litres remaining before refuelling (based on brimming the tank), hence the 250 mile range.
I have got up to a best of 69 MPG from this bike with 65 MPG easily returned when the throttle was used a bit more liberally and down to a lowest return of 63 MPG when running on 10% ethanol mixture ( French fuel that claimed to be 95 RON – before I saw the 10% sign it was in the tank!).




Suspension:
They come with preload and rebound adjustment on both the shock absorber and the front forks. Nevertheless, I have fiddled with all of these adjustments but I still consider the ride to be worse than other bikes I have owned (most recently ridden has been a F650GS which had a much softer suspension). The Versys seems to be harsh and my pillion has made the same comment, feeling every bump in the highway. Now I have everything, front and back, adjusted to the softest settings but it is disappointing for the quality of ride on anything but very smooth surfaces. Also, the forks are upside down in design (I've never owned one of these designs before) and I expected more from this suspension arrangement.
As a comment, as with most Hondas, the competitive pricing of the Versys may be achieved by economising in the suspension.


Engine:
The quoted horsepower is not a lot for a parallel twin 650cc, but that is OK for me, riding one up. The riding experience is about more than outright HP and it gives the impression of a decent amount of torque which is what I would expect from any twin cylinder. I have found the bike more than OK for one up riding, including with luggage fitted, but a bit breathless for carrying two people who more or less equate to the maximum all-up weight recommendation of Kawasaki.
I guess this means that the engine is doing pretty much what it was designed for, so, overall I consider this to be a good engine with good performance coupled with good fuel economy. It has more vibration than I expected after reading the reports comparing this version with the first, but I probably expected too much and I shouldn't have done after owning V twins.


Finish:
Yep, the plasticky bits are a matter of taste I suppose, but the polished alloy bits do mark easily and those marks can be just about anywhere that something touches the bike, including the matt paint on the fuel tank.
Sure, this doesn't matter one bit for an off road bike but this is a bike that is designed for the road and competing with other bikes that, arguably, have a more robust finish.




I guess that will do, for now.

Footnote regarding the engine: at an indicated 70 MPH (the legal speed in the UK for the motorway) the bike is pulling about 5500 revs, but it feels a bit high for that cruising speed. The engine is not "strained" at those revs, but it does feel like a higher engine revolution than I am used to.

Excellent review Walkabout.

I have managed as low as 50.86mpg with my short commutes and about town, which is still not bad.

As for the pegs, I lowered them with this kit

Lowering Foot Pegs Blocks

and since then no knee pain at all.

Thanks for that link; the lowering system looks like a good bit of kit and well made.

Ride magazine runs tests of fuel economy for a wide range of bikes over a standardised route under what they say is standardised riding.
The Versys lies 12th in their chart with a MPG figure of 56.7 MPG.

The best, by the way, is the KTM Duke 690 with 78.2 MPG which is hard to explain for a fairly-high-state-of-tune bike.
(The BMW single cyl models come close behind alongside the Honda NC700X).

I had the local Blacksmith weld the Kawasaki top box carrier to the pannier frames.
20K later not had any issues nor signs of stress fractures/fatigue

Nice job so long as it doesn't interfere, too much, with removing the pannier frames (on the occasions when you really don't want them fitted).

I would think that Kawasaki is most concerned for the sub-frame when riding two up with the luggage for two people (they would certainly be if they saw what my wife thinks should be fitted into panniers etc!).
My guess is that you were riding solo for most of those 20K miles??

Panniers frames stay on so not a problem for us.
Yes, the Versys is only ever ridden solo- it's my wife's Bike although I've borrowed it for a few European trips.

I got a 2012 Versys last weekend! I owned a 2008 model for few years until we moved for a year and a half to Brazil, where I got an er 6n.

Now, back in LondonV I am absolutely delighted to have another versys. I loved my previous one. I broke my heart having to sell it!

I am just getting the seat scooped out at the moment and waiting for my lowering link from the US.
I can ride the bike as it stands but I am really on my tip toes (I'm only 1.63m or 5 foot 4? sth like that!) ...

Big trip to Romania planned in the summer! I can't wait. And as it has been mentioned, with the exhaust under the belly I can just throw a couple of soft panniers over and go!

:D

hello
only in french, sorry, but went to Mongolia and is in south america nowadays
maxautourdumonde | vagabondagesautourdumonde
Maxime Barat
enjoy the pictures
cheers

Quite impressive. I never thought the Versys could do so much. My main concern would still be the exhaust under the belly. HE did not seem to have any issues with it but it would worry me a lot! In any cases most "pistes" are doable with any bike. I did quiet few trails in Brazil with my then er 6n, taking it easy and with road tyres....

I presume no threat of rain since the front mudguard was removed. The exhaust maybe low down, but it appears robust and my main concern would be flooding. Not a problem is the desert!

Great blog.

hello
mud guard dommage when he crashed
did you notice he uses same tires front and rear, and will exchange them ?
no noticed problem for the exhaust when he crossed rivers in Mongolia
cheers

I'm hopefully going to have a Versys very soon!

The local Harley garage has one, 2010 reg, 1,500 miles - no extras on it though

I had also been considering a 2009 one in Kawasaki Green :thumbup1: top box and hand guards, but it's got 15,000 miles on the clock so I think the Harley one is the better option (as they're the same price) ?

versys tourer
 

Had mine about 9 months, did about 900 ml before it's first service:oops2::nono: but my dealer told me not to worry as the warrantee is good:innocent:, now done about 1200 bedding in nicely still vibey compared to the 2009 version i had, but there are still a great machinebier
as for the luggage issues mine arrived as the tourer with side cases, at my request my dealer fitted / modified the topbox bracket (givi) to fitt so i have the best of worlds when needed:D
TDMalcolm

Grrr - Bike was sold :( - Carrying on looking!

TDMalc,
I have never been on the earlier version, but this latest one is reputed to be a smoother engine, in part because of improved mounting of the engine to the bike frame. ?c?

Apart from that, how do you rate the suspension of the current KLE650?

Well I jumped in and have bought a 2007 Versys for my planned RTW trip in 2014.. I read lots of mod threads on kawasakiversys.com and after sitting on one in a local dealer and comparing it to a tenere I decided it would be just as much up to the job.. after I have modified it to my own satisfaction. A alrge part of my trip will be road work and i think a twin will handle that better than a single.

In the end what swung it was rememering I rode a 1989 Yamaha FZ750 down to the edge of the Sahara in the 90's with very little preparation.

here it is as it stands right now.

http://farm9.staticflickr.com/8540/8...63da41e5_z.jpg

I have a lot of plans to turn it into the "adversys" it needs to be.. but that will come with time.

http://farm9.staticflickr.com/8266/8...10773203_z.jpg

list of things off the top of my head
Crash bars
bash plate (custom made)
Spot lights
Handguard
Short levers
re-upholstered seat - to increase the seat height
reworked front forks
R1 rear shock - resprung
lower shock linkage adapter to raise the ride height ?
Aluminium panniers
dual sport tyres
Replace all wheel bearings, brakes hoses etc etc
probably some other stuff that I cant think of right now

Should be fun !

Well been a little while since the last update.. Still saving hard, but tempering that with what I need to spend to sort out the bike and paperwork and... well just stuff I need to do !

The bike has had a few minor mods so far..I'm off work in August and plan to get the bash plate and some crash bars sorted..Look at fitting an alternative shock, mount some spotlights and the pannier racks .. I have a set of DARR BOX ali panniers and have so fitted a radiator guard.. upper and lower mudguard off a KTM950SM, a set of brush guards, heated grips, an MRA screen and added some addition foam to the seat to lift it a bit more for my extra long legs!

Heres the progress so far..
http://farm6.staticflickr.com/5525/9...47f28e3f_z.jpg

Been away touring. The Vango Banshee 200 tent fits perfectly into the pannier.

http://farm4.staticflickr.com/3818/8...d04a3fd2_c.jpg

Tent and some bits and pieces go in one pannier, my clothes in the other and sleeping bag in the top box. My sleep mat is on the pillion seat. That was me away for 5 days. There is still space for a few more bits, such as a camping stove.

updated pics.. just a few obs left to do before the end of April

http://farm8.staticflickr.com/7388/1...5c06acce_c.jpg

http://farm8.staticflickr.com/7380/1...f8de2b12_c.jpg

Now at 14014 miles and still going strong. The only failure has been an indicator bulb. I have just fitted a Metzeler Roadtec Z6 rear tyre to replace the the previous one which finally flattened out after a very long motorway trek.

I bought a left-over '12 U.S. Versys last November and have put about 10,000 miles on it. Went with a 16T front sprocket to lower highway rpm and a Kaoko throttle lock. Replaced the stock tires with Michelin Pilot Road 4s and added a Scottoiler. I am getting about 55 mpg at 70 mph.

Versys 650 – Stage 1 | Adventure Motorcycling Handbook
Some interesting reading is in the link.
Especially the solution to the very harsh standard suspension and the bodge job that can be done with a length of wire for on board diagnostics (OBD).

New to the V-clan :D
My 07 Orange beastie

http://i1206.photobucket.com/albums/...ps6rzaura8.jpg

Kazakhstan
https://c1.staticflickr.com/1/383/19...74bcf459_z.jpg

Kazakhstan
https://c1.staticflickr.com/1/309/20...41ee8dbe_z.jpg

Siberia
https://c2.staticflickr.com/6/5620/2...431c4165_z.jpg

Russia
https://c1.staticflickr.com/1/570/20...a9334939_z.jpg

Australia
https://c2.staticflickr.com/6/5695/2...c83285c4_z.jpg

Great ocean road
https://c2.staticflickr.com/2/1594/2...da21d358_z.jpg



Bike was perfect in all conditions... better than a single cylinder bike and lighter than a huge BMW/KTM adventure bike..

Highly recommended as a very capable long distance motorcycle.

25k miles and the only thing that failed was a rear wheel bearing

:thumbup1:

https://www.youtube.com/watch?v=9Vu0OQyQL6Y

Good review of new 2015 Versys 650 against DL650 Vstrom and Honda NC700X.
The Versys pretty much one the day, but it was mostly price that put them off the more expensive Vstrom. But the Versys was still superior on a twisty road, more fun to ride, according to journalists.