Go Back   Horizons Unlimited - The HUBB > Technical, Bike forums > Kawasaki Tech
KLE500 - fuel consumption ?? excessive KLE500 - fuel consumption ?? excessive
Register FAQ Calendar Today's Posts
Kawasaki Tech Kawasaki Tech Forum - For Questions specific and of interest to Kawasaki riders only.
Photo by Lois Pryce, schoolkids in Algeria

25 years of HU Events


Destination ANYWHERE...
Adventure EVERYWHERE!




Photo of Lois Pryce, UK
and schoolkids in Algeria



Reply
Page 1 of 3 1 23
 
LinkBack Thread Tools Display Modes
  #1  
Old 27 Jan 2008
Registered Users
New on the HUBB
  
Join Date: Jan 2008
Location: UK
Posts: 2
KLE500 - fuel consumption ?? excessive
Hi Everyone,

I'm new to the board and to KLEs but have been biking for a very long time. I 'm hoping you guys that know these bikes can answer a question for me....

I have a 95 KLE (no cats) and like it a lot APART from the fuel consumption - basically getting around 40mpg commuting on tarmac. This seems a lot! I am travelling at an indicated 70-80 quite a lot of the time but on the same trip (60miles one way) my 1500cc car is the cheaper option fuel wise (and about same speed!).

Is this normal? The bike is fairly low mileage - 11.5k miles and is serviced well although I have to confess I have not yet replaced the air filter as it looks very clean.

I was hoping for 50+ MGP ....... but have found I can not do a 'whole' round trip without refueling whioch is anoying!

Has anyone any thoughts other than go slower?

Cheers

Frog
Reply With Quote
  #2  
Old 27 Jan 2008
royzx7r's Avatar
Contributing Member
Veteran HUBBer
  
Join Date: Mar 2007
Location: Liverpool UK
Posts: 225
Hi Frog,

Mines a 2006 KLE but is being strangled by the cat. I get about 130 miles before she coughs and I have to switch to reserve.

If I boot it, then it could be as low as a 100miles. At 70mph you should do the 120miles round trip without going to reserve. are the carbs in need of a balance or mabey theres a build up of carbon in the jets.

I run a one shot of fuel cleaner in my tank evey so often to stop the build up of carbon.

Hope this helps

Roy
__________________
"Whats in that thing??", An R1 owner said.
Reply With Quote
  #3  
Old 28 Jan 2008
Registered Users
Veteran HUBBer
  
Join Date: Feb 2006
Posts: 1,598
Just try it once sticking to the speed limits and maintaining a steady speed... It is my experience that the right wrist is the biggest factor of mpg. My own 1985 BMW R80RT mpg jumped froma bout 50mpg to 57 when I accompanied a diesel enfield to the german diesel bike rally. We were doin mostly 55-65 mph. Not bad for 9hp

Despite the increase in my mpg pleasing me, my companions mpg was somewhere between 150 and 180 mpg and he had to keep stopping to wait for me to refuel.
Reply With Quote
  #4  
Old 29 Jan 2008
Registered Users
HUBB regular
  
Join Date: Jul 2006
Location: N.E.Essex
Posts: 37
Fuel consumption.
Hi Frog, it might be worth playing around with sprocket sizes. I believe earlier KLE's ran 46teeth rear, '05 models use 44teeth. It will drop the revs a bit for the same speed. I use a 42teeth sprocket and it's ok unless there is a strong headwind. I normally get 55-60 mpg at 70ish mph.

Enjoy the ride.

Regards, Richard.

p.s. I had to take out two links for the smaller rear sprocket.
Last edited by wobbly; 29 Jan 2008 at 00:05. Reason: Bad grammer.
Reply With Quote
  #5  
Old 2 Feb 2008
Registered Users
New on the HUBB
  
Join Date: Jan 2008
Location: UK
Posts: 2
Thanks everyone.

I'll try a steadier run and see what happens.

The sprocket change is an interesting idea - I guess it would mean a new chain as well.........

I'll give the filter another clean and maybe dry it a little more (- maybe it's over oiled???) and resync the carbs while I'm there - they do feel a little out although only just done!

Cheers

Frog
Reply With Quote
  #6  
Old 9 Feb 2008
Registered Users
HUBB regular
  
Join Date: Jun 2007
Location: Devon, England
Posts: 26
fuel
A few weeks ago I did a few calculations on fuel consumption.

When I was motorway riding at a stady 60mph I was getting 64mpg (14.3 miles per litre).

If I stayed at that speed for the complete tank capacity I would run out after roughly 210 miles.

When I rode at 75-85mph mph on a journey having filled up the tank full at the beginning of the journey I had to turn to reserve after 102 miles :-(

On town riding / commuting at speeds varying from 10 - 50mph, stopping and starting I am getting 50mpg (12.5 miles per litre), this is with cafeful riding, slow accelaration, smooth revs.
Last edited by voleurs; 26 Mar 2008 at 23:39.
Reply With Quote
  #7  
Old 27 Feb 2008
Registered Users
HUBB regular
  
Join Date: Feb 2008
Location: Switzerland
Posts: 20
Hey guys,

in the german community a so called rimfire-conversion is famous to reduce the amount of fuel seriously. We usually count in liters used in 100 km. Usually it is around 6 - 7 Liter a 100km for the KLE and with that conversion you should be able to reduce it to 5 - 5,5 liter a 100km.
It consists of making holes in the airfilterbox. The only thing is that the early KLEs (1991- around 1996) have a different Airfilterbox than the newer onces (I dont know about the very knew KLEs). So be aware that the conversion is not the same for both.

here is the link: It's in german I know, I can translate it if someone wants me to... http://winweb373.sr23.firestorm.ch/t...ltertuning.pdf

It is not a legal modification! But I think it could be somehow usefull.

Cheers
Micki
Reply With Quote
  #8  
Old 25 Mar 2008
Registered Users
New on the HUBB
  
Join Date: Mar 2008
Location: New Zealand
Posts: 3
12 months of figures...
Bought my KLE new 15 months ago and decided to do the exercise myself. My riding varies from offroad to highway and has mostly been highway for the past 6 months. I travel at a moderate speed off road and have been known to give the girl a caning on the highway so have figures for a wide variety of styles.

My consumption has only ever varied from 20-22klm's/litre (that's 56-62mpg in the UK or 47-52mpg in the US). Distance per tank is 300-340 kilometres.

In order to better this I bought a new sprocket today (standard is 46 teeth/new one is 43 teeth). This will drop the gear ratio from 3.29 to 3.07. I've also switched from a knobby to a road tyre (not sure if this will have any effect).

Give me a week and I'll post results of the change.
Reply With Quote
  #9  
Old 26 Mar 2008
TDMalcolm's Avatar
Registered Users
Veteran HUBBer
  
Join Date: May 2007
Location: norfolk uk
Posts: 140
fuel figs
Hi All, My '07 reg kle returns on average 120-156mles to reserve, depending how twist the right hand 97% tarmac odd green lanes and my deep gravel drive no mods to engine and cats installed etc....
TDMalcolm
Reply With Quote
  #10  
Old 28 Mar 2008
Registered Users
New on the HUBB
  
Join Date: Mar 2008
Location: New Zealand
Posts: 3
Update to last post...
Bike shop steered me wrong on sprocket details (noticed this only when the rear wheel was in pieces on the garage floor and scraped the grease off the side of the sprocket). Seems the standard rear is 44 teeth and front is 17. In order to get the same drop in gear ratio will have to go to a 38 on rear and 16 on front. May be a month or so to order the 38 from overseas. Keep you posted.
Reply With Quote
  #11  
Old 29 Jun 2008
Registered Users
HUBB regular
  
Join Date: Apr 2008
Location: ENGLAND
Posts: 23
Having just calculated fuel use over an initial 1500miles on a new KLE I can concur that I am getting between 56-71 miles per gallon (20-25 km per litre). Obviously running in the machine has limited the twist of the right wrist but at the same time the engine should be starting to free up. Half of the distance has been covered with a passenger along. While the weight and dynamics maybe affected consumption with having a passenger I am sure the dig in the ribs from the mrs to slow down may balance this out.

Neil
Reply With Quote
  #12  
Old 30 Jun 2008
muthaf9cka's Avatar
Registered Users
Veteran HUBBer
  
Join Date: Jun 2006
Location: London
Posts: 124
My fuel consumption has improved dramatically (20% or so) since it topped about 13,000 miles and I switched to Avon Roadriders. I used to get around 45-50mpg and now get around 60mpg. To be honest, I'm not sure whether it was the engine freeing up a bit more or the tyres, but the sidewind stability improved a lot when I ditched the pretend off-road tyres.
__________________
"On that? You're nuts!" - My cousin's boyfriend

Current Bikes - Kawasaki KLE500 '05 (May 06)
Previous Bikes - Hyosung GF125 (Oct 05 to May 06)
Reply With Quote
  #13  
Old 9 Jul 2008
Registered Users
HUBB regular
  
Join Date: Jun 2008
Location: NSW, Australia
Posts: 62
I rate my fuel consumption as average. I too experienced exceptional mileage during running in, simply because rpm's stayed below 4500.

These days (23000km) commuting at 100-120kmh, my KLE hits reserve between 184km and 195km from full. This means that apprehension about pushing the thing sets in at around 240km from full. I have had to do so after using the old "lay the bike on the left side" trick to drain the right side of the tank until it was dry. good news was that the push was only half a kay to the servo - nice!!

Cheers
Ian
Reply With Quote
  #14  
Old 15 Jul 2008
Registered Users
HUBB regular
  
Join Date: Jul 2008
Location: Brisbane Aussie
Posts: 32
K's
Quote:
Originally Posted by Jameseye View Post
I rate my fuel consumption as average. I too experienced exceptional mileage during running in, simply because rpm's stayed below 4500.

These days (23000km) commuting at 100-120kmh, my KLE hits reserve between 184km and 195km from full. This means that apprehension about pushing the thing sets in at around 240km from full. I have had to do so after using the old "lay the bike on the left side" trick to drain the right side of the tank until it was dry. good news was that the push was only half a kay to the servo - nice!!

Cheers
Ian
I thought 230klm to reserve was bad. I Filled up and got 254K's on 11.8 Ltrs. This is it's second tank of fuel I've put in. I'm new to the KLE world I just picked it up 2 weeks ago New But 2007 plate.
It works out roughly 21.5 ks to the L or 4.6L Per 100Ks
__________________
Fun begins when the bitumin ends!
Reply With Quote
  #15  
Old 16 Jul 2008
Registered Users
HUBB regular
  
Join Date: Feb 2008
Posts: 28
I get about 230-240 before hitting reserve. 25000 kms on the clock

Will
Reply With Quote
Reply
Page 1 of 3 1 23

« Previous Thread | Next Thread »

Currently Active Users Viewing This Thread: 1 (0 Registered Users and/or Members and 1 guests)
 

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On

Similar Threads
Thread Thread Starter Forum Replies Last Post
Fuel consumption & range Kpick BMW Tech 5 24 Sep 2008 06:35
Estimating fuel consumption...! danward79 Equipping the Overland Vehicle 20 15 Nov 2007 18:38
Bm fuel consumption and Bodge up floyd BMW Tech 2 9 Mar 2007 22:06
XR650L - What fuel consumption off-road in desert? mattmbishop Honda Tech 4 30 Jan 2006 00:32
Fuel Consumption highway Yamaha Tech 2 22 Dec 2003 17:50

 
 

Announcements

Thinking about traveling? Not sure about the whole thing? Watch the HU Achievable Dream Video Trailers and then get ALL the information you need to get inspired and learn how to travel anywhere in the world!

Have YOU ever wondered who has ridden around the world? We did too - and now here's the list of Circumnavigators!
Check it out now, and add your information if we didn't find you.

Next HU Eventscalendar

25 years of HU Events
Be sure to join us for this huge milestone!

ALL Dates subject to change.

2025 Confirmed Events:

Virginia: April 24-27
Queensland is back! May 2-5
Germany Summer: May 29-June 1
Ecuador June 13-15
Bulgaria Mini: June 27-29
CanWest: July 10-13
Switzerland: Aug 14-17
Romania: Aug 22-24
Austria: Sept. 11-14
California: September 18-21
France: September 19-21
Germany Autumn: Oct 30-Nov 2

Add yourself to the Updates List for each event!

Questions about an event? Ask here

See all event details

 
World's most listened to Adventure Motorbike Show!
Check the RAW segments; Grant, your HU host is on every month!
Episodes below to listen to while you, err, pretend to do something or other...

Adventurous Bikers – We've got all your Hygiene & Protection needs SORTED! Powdered Hair & Body Wash, Moisturising Cream Insect Repellent, and Moisturising Cream Sunscreen SPF50. ESSENTIAL | CONVENIENT | FUNCTIONAL.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

2020 Edition of Chris Scott's Adventure Motorcycling Handbook.

"Ultimate global guide for red-blooded bikers planning overseas exploration. Covers choice & preparation of best bike, shipping overseas, baggage design, riding techniques, travel health, visas, documentation, safety and useful addresses." Recommended. (Grant)



Ripcord Rescue Travel Insurance.

Led by special operations veterans, Stanford Medicine affiliated physicians, paramedics and other travel experts, Ripcord is perfect for adventure seekers, climbers, skiers, sports enthusiasts, hunters, international travelers, humanitarian efforts, expeditions and more.

Ripcord Rescue Travel Insurance™ combines into a single integrated program the best evacuation and rescue with the premier travel insurance coverages designed for adventurers and travel is covered on motorcycles of all sizes.
(ONLY US RESIDENTS and currently has a limit of 60 days.)

Ripcord Evacuation Insurance is available for ALL nationalities.


 

What others say about HU...

"This site is the BIBLE for international bike travelers." Greg, Australia

"Thank you! The web site, The travels, The insight, The inspiration, Everything, just thanks." Colin, UK

"My friend and I are planning a trip from Singapore to England... We found (the HU) site invaluable as an aid to planning and have based a lot of our purchases (bikes, riding gear, etc.) on what we have learned from this site." Phil, Australia

"I for one always had an adventurous spirit, but you and Susan lit the fire for my trip and I'll be forever grateful for what you two do to inspire others to just do it." Brent, USA

"Your website is a mecca of valuable information and the (video) series is informative, entertaining, and inspiring!" Jennifer, Canada

"Your worldwide organisation and events are the Go To places to for all serious touring and aspiring touring bikers." Trevor, South Africa

"This is the answer to all my questions." Haydn, Australia

"Keep going the excellent work you are doing for Horizons Unlimited - I love it!" Thomas, Germany

Lots more comments here!



Five books by Graham Field!

Every book a diary
Every chapter a day
Every day a journey
Refreshingly honest and compelling tales: the hights and lows of a life on the road. Solo, unsupported, budget journeys of discovery.
Authentic, engaging and evocative travel memoirs, overland, around the world and through life.
All 8 books available from the author or as eBooks and audio books



Back Road Map Books and Backroad GPS Maps for all of Canada - a must have!

Your ad could be here, on EVERY page of the HUBB, or the whole website, or as many as you like!

New to Horizons Unlimited?

New to motorcycle travelling? New to the HU site? Confused? Too many options? It's really very simple - just 4 easy steps!

Horizons Unlimited was founded in 1997 by Grant and Susan Johnson following their journey around the world on a BMW R80G/S.

Susan and Grant Johnson Read more about Grant & Susan's story

Membership - help keep us going!

Horizons Unlimited is not a big multi-national company, just two people who love motorcycle travel and have grown what started as a hobby in 1997 into a full time job (usually 8-10 hours per day and 7 days a week) and a labour of love. To keep it going and a roof over our heads, we run events all over the world with the help of volunteers; we sell inspirational and informative DVDs; we have a few selected advertisers; and we make a small amount from memberships.

You don't have to be a Member to come to an HU meeting, access the website, or ask questions on the HUBB. What you get for your membership contribution is our sincere gratitude, good karma and knowing that you're helping to keep the motorcycle travel dream alive. Contributing Members and Gold Members do get additional features on the HUBB. Here's a list of all the Member benefits on the HUBB.



All times are GMT +1. The time now is 11:41.

Contact Us - Horizons Unlimited Motorcycle Travellers Website - Archive - Privacy Statement - Top