Doesn't like the cold!

[BlackDogZulu]

3TB, 1994, 26k miles.

Minor issue, but would appreciate your views. Starting point: bike is starting and running well. In fact, it's never been better. Pull the choke, engine starts within 2-3 turns, good fast idle, choke off within half a mile and then runs and idles correctly. Ran fine all the way through last winter, too.

The last couple of mornings have been below zero, perhaps -3C. It's been a lot harder to start, firing 3-4 times and dying before getting going with the throttle cracked quarter of a turn and held there. That's not too bad, but once it's properly warm (after 10+ miles of 60mph plus) it's trying to die if I back off the throttle (e.g. changing down for a roundabout). This morning was warmer, and the bike started and ran fine.

It's not a big deal, especially as summer is coming, but it looks as though something has deteriorated since last winter. It feels a bit like carb icing, but I didn't think that was an issue with these bikes. Any ideas before I start tearing it apart?

[Mezo]

Spark plug? one that would suit colder conditions?

Move to a warmer place?

Mezo.

[bacardi23]

increase pilot jet!

[BlackDogZulu]

Originally Posted by Mezo

Spark plug? one that would suit colder conditions?

Plug was replaced 1200 miles ago, with DPR8EA-9 as always. I've had the same heat range plug since I have owned the bike, and this is a new issue, so I doubt if the plug is the cause.

Originally Posted by Mezo

Move to a warmer place?

Good idea. When I win the lottery, definitely.

Originally Posted by bacardi23

increase pilot jet!

As above, carb jets and settings haven't been touched for 3 years, and it ran OK last winter, which was a lot colder than this one.

Thanks for your ideas.

[Gipper]

If the plug, ignition and lead are ok and you are getting a good spark, air filter is good and timing is good and the motor has good compression start looking at fuel flow issues:
- any water in the fuel? - try fresh petrol.
- is petcock working ok - is it vacuum operated?
- clogged fuel filter?
- any air leaks in fuel system?
- stuck or leaking float?
- is choke working properly (at carb)
-any gumming or deposits on idle screw or jets or in carb in general?
- worn jets?

good luck

[BlackDogZulu]

Hi Gipper

Bike was recently serviced and is in daily use, so fuel should be good. And of course nothing fancy like fuel filters or vacuum petcocks I'd also rule out a problem with the choke as the near-stalling happens after 15 mins hard running, when the engine is thoroughly warm.

I'm more inclined towards the idea of an air leak, although I replaced the carb rubbers 2 years ago to cure a misfire and they seem good. As the problem seems to have developed over time, carb deposits or worn jets could also be in the frame. What's bugging me is that, as long as the temp is above zero, the bike is running well. In fact, but better than it ever has (starting, idling, power output etc).

Looks like the carb is where it's at. Unless it's compression - hadn't thought of that, and it hasn't been checked for about 2 years. Time for a look-see when I next get a day off. Thanks for the input.